Journal of food science and technology(Iran)

Journal of food science and technology(Iran)

Post-Harvest Processing of Okra (Abelmoschus esculentus L.): A Comparative Review of Drying, Freezing, and Emerging Fermentation Approaches on Phytochemical Stability and Bioactivity

Document Type : Original Article

Authors
Mustafa Khaled 1
Ahlam zakir 2
Hajar Falih 2
1 Univesity of Fallujah, College of Education, Department of Life Sciences, Iraq
2 Univesity of Fallujah, College of applied science, Department of biotechnology
10.48311/fsct.2026.119358.83067
Abstract
Abstract
Okra (Abelmoschus esculentus L.) is a nutrient-rich vegetable, which is inherently very perishable and mainly because it has a high moisture content (8890 ‛ ). As a result, the maintenance of its phytochemical profile requires the introduction of the appropriate post-harvest technologies. The aim of this review is to offer a comparative analysis of the effectiveness of various post-harvest modalities such as: hot air drying (HAD), microwave-vacuum drying (MVD), freeze-drying (FD), infrared drying (ID), and natural convective drying (NCD), and between freezing and blanching pre-treatment in protecting the phytochemical contents of okra. Based on the literature review, it has been observed that freeze-drying is the best post-harvesting technology in preserving the phytochemical composition of okra in terms of the retention of total phenolic content, total flavonoid content, antioxidant activity, vitamin C, and chlorophyll content. However, the process is energy-intensive and requires a longer processing time. Hot air drying at a moderate temperature (50-60°C) is a cost-effective method, but the phytochemical composition of okra is found to degrade considerably. Microwave-vacuum drying is a relatively faster method than hot air drying. Freezing is also found to be effective in preserving the phytochemical composition of okra, but the process requires a continuous supply of electrical energy. Blanching pre-treatment using steam or hot water is found to be effective in preserving the phytochemical composition of okra, but the process results in the loss of water-soluble phenolics and antioxidant compounds. Blanching pre-treatment also enhances the content of carotenoids like β-carotene in okra
Keywords
Abelmoschus esculentus
Drying Methods
Freezing
Blanching
Phytochemicals
Antioxidant Activity
Subjects
[1] Durazzo, A., Lucarini, M., Novellino, E., Souto, E. B., Daliu, P., & Santini, A. (2019). Abelmoschus esculentus (L.): Bioactive components’ beneficial properties—Focused on antidiabetic role—for sustainable health applications. Molecules, 24(1), 38. https://doi.org/10.3390/molecules24010038
[2] Shen, D.-D., Li, X., Qin, Y.-L., Li, M.-T., Han, Q.-H., Zhou, J., Lin, S., Zhao, L., Zhang, Q., Qin, W., & Wu, D.-T. (2019). Physicochemical properties, phenolic profiles, antioxidant capacities, and inhibitory effects on digestive enzymes of okra (Abelmoschus esculentus) fruit at different maturation stages. Journal of Food Science and Technology, 56(3), 1275-1286. https://doi.org/10.1007/s13197-019-03592-1
[3] Wu, D.-T., Nie, X.-R., Shen, D.-D., Li, H.-Y., Zhao, L., Zhang, Q., Lin, D.-R., & Qin, W. (2020). Phenolic compounds, antioxidant activities, and inhibitory effects on digestive enzymes of different cultivars of okra (Abelmoschus esculentus). Molecules, 25(6), 1276. https://doi.org/10.3390/molecules25061276
[4] Aamir, M., & Boonsupthip, W. (2017). Effect of microwave drying on quality kinetics of okra. Journal of Food Science and Technology, 54(5), 1239-1247. https://doi.org/10.1007/s13197-017-2546-3
[5] Huang, J., & Zhang, M. (2016). Effect of three drying methods on the drying characteristics and quality of okra. Drying Technology, 34(8), 900-911. https://doi.org/10.1080/07373937.2015.1086367
[6] Li, H., Xie, L., Ma, Y., Zhang, M., Zhao, Y., & Zhao, X. (2019). Effects of drying methods on drying characteristics, physicochemical properties and antioxidant capacity of okra. LWT - Food Science and Technology, 101, 630-638. https://doi.org/10.1016/j.lwt.2018.11.076
[7] Wang, H., Zhao, Q., & Zhao, B. (2019). Comparison of drying methods on drying efficiency and physicochemical quality of okra (Abelmoschus esculentus) cultivated in China. Journal of Food Process Engineering, 42(6), e13163. https://doi.org/10.1111/jfpe.13163
[8] Samakradhamrongthai, R. S., Nortuy, N., Jannu, T., Supawan, T., Chanakun, P., Yimkaew, Y., & Renaldi, G. (2022). Influence of three drying methods on physicochemical properties of okra (Abelmoschus esculentus L.) powder. Journal of Food Processing and Preservation, 46(3), e16381. https://doi.org/10.1111/jfpp.16381
[9] El-Mesery, H. S., & Elabd, M. A. (2021). Effect of microwave, infrared, and convection hot-air on drying kinetics and quality properties of okra pods. International Journal of Food Engineering, 17(11), 909-926. https://doi.org/10.1515/ijfe-2021-0125
[10] Al-Dabbas, M. M., Moumneh, M., Hamad, H. J., Abughoush, M., Abuawad, B., Al-Nawasrah, B. A., Al-Jaloudi, R., & Iqbal, S. (2023). Impact of processing and preservation methods and storage on total phenolics, flavonoids, and antioxidant activities of okra (Abelmoschus esculentus L.). Foods, 12(19), 3711. https://doi.org/10.3390/foods12193711
[11] Rababah, T. M., Al-U’datt, M. H., Angor, M., Gammoh, S., Abweni, F., Magableh, G., Almajwal, A., Yücel, S., AL-Rayyan, Y., & AL-Rayyan, N. (2023). Effect of drying and freezing on the phytochemical properties of okra during storage. ACS Omega, 8(38), 34448-34457. https://doi.org/10.1021/acsomega.3c02560
[12] Reid-Fitten, M. L., Cotton, C. P., Min, B. R., Nindo, C. I., & Williams, Z. F. (2026). Effects of thermal pre-treatments and drying processes on the retention of phytonutrients, vitamins, and antioxidant activity in dried okra (Abelmoschus esculentus L.). Foods, 15(2), 311. https://doi.org/10.3390/foods15020311
[13] Adetuyi, F. O., & Ibrahim, T. A. (2014). Effect of fermentation time on the phenolic, flavonoid and vitamin C contents and antioxidant activities of okra (Abelmoschus esculentus) seeds. Nigerian Food Journal, 32(2), 128-137. https://doi.org/10.1016/S0189-7241(15)30128-4
[14] Wang, X., Hu, K., Chen, Y., Lai, J., Zhang, M., Li, J., Li, Q., Zhao, N., & Liu, S. (2024). Effect of Lactiplantibacillus plantarum fermentation on the physicochemical, antioxidant activity and immunomodulatory ability of polysaccharides from Lvjian okra. International Journal of Biological Macromolecules, 257(Pt 1), 128649. https://doi.org/10.1016/j.ijbiomac.2023.128649
[15] Prior, R. L., Wu, X., & Schaich, K. (2005). Standardized methods for the determination of antioxidant capacity and phenolics in foods and dietary supplements. Journal of Agricultural and Food Chemistry, 53(10), 4290-4302. https://doi.org/10.1021/jf0502698
[16] Karadag, A., Ozcelik, B., & Saner, S. (2009). Review of methods to determine antioxidant capacities. Food Analytical Methods, 2(1), 41-60. https://doi.org/10.1007/s12161-008-9067-7
[17] Yuan, Q., He, Y., Xiang, P.-Y., Huang, Y.-J., Cao, Z.-W., Shen, S.-W., Zhao, L., Zhang, Q., Qin, W., & Wu, D.-T. (2020). Influences of different drying methods on the structural characteristics and multiple bioactivities of polysaccharides from okra (Abelmoschus esculentus). International Journal of Biological Macromolecules, 147, 1053-1063. https://doi.org/10.1016/j.ijbiomac.2019.10.073